Product ID:GLOSS YELLOW ENAMEL 595-13538 LEAD FREE,(SU
MSDS Date:01/01/1989
FSC:8010
NIIN:00N018079
MSDS Number: BKZMG

CROWN METRO AEROSPACE COATINGS INC

GREENVILLE, SC 29606
US

Emergency Phone: 803-277-1870

Info Phone: 803-277-1870

Cage: CROME

CROWN METRO AEROSPACE COATINGS INC

5695 GREENVILLE, SC 29606 US

Telephone: 803-277-1870

Cage: CROME

POLYAMIDE RESIN; (ORGANIC AMINE COMPLEX)

CAS: 68410-23-1

Fraction By Weight: <20%

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <15%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <10%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: <5%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CYCLOHEXANONE (SARA III)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: <5%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN & RESP TRACT: CAN CAUSE
IRRIT. SYMP MAY BE WATERING OF EYES, DRYNESS OF THROAT, COUGHING,
HDCH, TIGHTNESS IN CHEST OR BURNING SENS. ALLERGIC RXN MAY OCCUR IN
SOME PEOPLE,HDCH, DIZZ OR NAUS M AY BE EXPERIENCED BY SOME AS
RESULT OF SOLVENTS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:PERSONS W/ASTHMATIC TYPE CONDITION,
CHRONIC BRONCHITIS OR OTHER CHRONIC RESP DISEASE OR RECURRENT SKIN
ECZEMA OR SENSATION SHOULD BE EXCLUDED FROM WORKING WITH THIS
PRODUCT.

First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINUTES. CONSULT MD. SKIN:
WASH AREA WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING. CONSULT
MD. INHAL: REMOVE TO FRESH AIR. CONSULT MD. INGEST: DRINK WATER TO
DILU TE. DO NOT INDUCE VOMITING. CONSULT MD.

Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1%
Extinguishing Media:USE NFPA CLASS B EXTINGUISHERS
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .KEEP
CNTNR TIGHTLY CLSD. ISOLATE FROM SPARKS/ELEC EQUIP/OPEN FLAMES. H20
SPRAY MAY BE INEFT. IF H20(SUPP DATA)
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPSD
TO EXTREME HEAT. APPLICATN TO HOT SURF REQ SPECIAL PREC. DURING
EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE(SUPP DATA)

Spill Release Procedures:EVACUATE NON ESSENTIAL PERSONNEL. REMOVE ALL
SOURCES OF IGNITION (SPARKS, FLAMES, HOT SURFACES). VENTILATE AREA.
EQUIP CLEAN UP CREW W/SCBA. DIKE SPILL. COVER WITH SAWDUST,
VERMICULITE, FULLER'S EARTH . COLLECT MATERIAL IN OPEN CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE >100F. STORE LARGE
QUANTITIES ONLY IN BUILDING DESIGNED TO COMPLY W/OSHA 1910.106.
KEEP CONTAINERS CLOSED AND UPRIGHT TO PREVENT LEAK.
Other Precautions:DO NOT STORE OR USE NEAR HEAT, SPARKS, OR FLAMES.
AVOID PROLONGED/REPEATED CONTACT WITH VAPOR OR SPRAY MIST DURING
APPLICATION OR CURING.

Respiratory Protection:OUTDOOR/OPEN AREAS USE NIOSH/MSHA APPROVED MECH
FILTER RESP. IN RESTRICTED VENT AREAS, USE NIOSH/MSHA APPRVD
CHEM/MECH FILTERS TO REMOVE VAPOR/PARTICULATES. IN CONFINED AREA
USE NIOSH/MSHA APPRVD AIR LINE TYPE RESP OR HOODS.
Ventilation:MUST BE SUFFICIENT IN VOL & PATTERN TO KEEP CONTAMINANT
CONC BELOW TLV OR PEL.
Protective Gloves:REQUIRED,BUTYL RUBBER RECOMMENDED.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY.
Work Hygienic Practices:WASH HANDS BEFORE EATING/USING BATHROOM. REMOVE
& WASH COMTAMINATED CLOTHING BEFORE REUSE. WEAR CHEM RESISTANT
BOOTS.
Supplemental Safety and Health
MFR PART NO: EC-132 (CURING SOLUTION). FIRE FIGHT PROC: WHEN EXPOSED TO
EXTREME HEAT. EXPLO HAZ: HEALTH HAZ. SYMP MAY NOT BE IMMED
APPARENT. CALL MD.

HCC:F3
Boiling Pt:B.P. Text:230F,110C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.162
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:60

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:TEMPS ABOVE MAX STORAGE TEMPS. AVOID
EXPOSURE TO HEAT, SPARKS, OR OPEN FLAMES.
Hazardous Decomposition Products:BY FIRE - CO, CO2, AND NITROGEN
OXIDES.

Waste Disposal Methods:CONFORM TO FEDERAL, STATE AND LOCAL REGULATIONS.
EMPTY CONTAINERS MUST BE HANDLIED CAREFULLY DUE TO PRODUCT RESIDUE
& FLAMMABLE SOLVENT VAPOR.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.